宁波杜凯软管有限公司NINGBO TUCAI
消防设备点检作业指导书FIRE EQUIPMENT CHECKING SOP 文件编号DOCUMENT NUMBER:NT/5S&EHS-13
一、消防栓的点检方法fire equipment checking method.
说明：
1，确认消防栓前方清晰的区域线标示避免其他物品堵塞，检查消火栓箱体有无变形，玻璃有无破损，箱门能否正常打开，破损时需联系相关单位及时修复。2，灭火器的点检方式：2.1检查压把和铅封是否完好；2.2.检查压力表指针是否指向红色区域，如是则为不正常；2.3.检查软管及喷头是否无破损，喷头是否堵塞；2.4.检查瓶身是否有变形破损，是否生锈严重；2.5.做好点检记录。
3，消防栓的点检方式：3.1.检查水、水带有无丟失，水带是否干燥﹐无破损﹐其接扣是否牢固能否正常投入使用；3.2.检查阀门有无漏水；3.3.目视检查报警系统是否处于正常状态；3.4.做好点检记录。Illustration:
1,check if the red tape front of fire hydrant clear and aviod other things to block,the body of fire cock box such as glass or topcan't be broken or dirty,if not then must repair and clean.
2,the checking method of fire extinguisher:2.1,check if the handle and bolt is OK or not;2.2,check if the pressure gauge hand pointthe red area, if yes then means it is unqualified;2.3,check if the hose and nozzle is broken, if the nozzle is blocked;2.4,check ifthe body is out of shape and broken, if the body rust seriously;2.5,finish the checking record.
3,the checking method of fire hydrant:3.1,check if the water gun,hose miss,if the hose dry and no broken;3.2,check if the valveleakage,3.4,check if the alarm system is normal by eye;3.4,finish the checking record.二、应急灯及安全出口灯点检方法emergency light and exit light checking method.
说明：
1，应急灯的点检方式：1.1.检查绿色工作指示灯是否工作正常，如红色指示灯亮则处于充电状态，如黄色指示灯亮则有故障；1.2.检查外壳有无破损；1.3.查看电池有无漏液现象发生；1.4.拔掉电源，检查应急照明灯能否正常照明，如正常工作则恢复电源供电；1.5.如以上检查结果全部OK，则在应急灯及安全出口灯点检表上签名确认；1.6.必須保证每月至少对应急照明灯放电养护一次（断开电源后自然完全放电再插上电源充电）。2，安全出口灯，疏散指示灯的点检：2.1.检查外壳有无破损；2.2.检查灯是否正常亮着。Illustration:
1,the checking method of emergency light:1.1,check if the green work indication lamp can light or not,if red indication lamp lightthen means it is charging, if yellow indication lamp light then means it is broken;1.2check if the shell broken or not;1.3,check ifthe battery is leakage or not;1.4,cut power,check if the emergency light can open or not, if it work normally then continue to
charge;1.5,if all of above item is OK,then please sign on the emergency light and exit light checklist to confirm;1.6,must to makesure discharge the emergency light to maintain every month at least(cut the power to discharge completely and link the power again).2,the checking method of exit light:2.1,check if the shell is broken or not;2.2,check if the lamp can light or not.编制Made by:邓平平Mike.deng
审核Approved by:
